Product ID:MT TONER II, EP4300
MSDS Date:01/31/1990
FSC:6850
NIIN:00N026581
MSDS Number: BNCVX

MINOLTA CORP

101 WILLIAMS DR
RAMSEY, NJ 07446
US

Emergency Phone: 201-825-4000

Info Phone: 201-825-4000

Cage: GO339

MINOLTA CORPORATION

RAMSEY, NJ 07446 US

Telephone: 201-825-4000

Cage: 23736

STYRENE ACRYLATE COPOLYMER

Fraction By Weight: >80%

COPPER OXIDE

CAS: 1317-38-0

RTECS: GL7900000

Fraction By Weight: 5-10%

OSHA PEL 0.1 MG/M3 FUME (CU)

ACGIH TLV: 0.2 MG/M3 FUME (CU)

ORGANIC PIGMENT

CAS: 32517-36-5

Fraction By Weight: 1-5%

CARBON BLACK

CAS: 1333-86-4

RTECS: FF5800000

Fraction By Weight: 1-5%

OSHA PEL 3.5 MG/M3

ACGIH TLV: 3.5 MG/M3

PROPENE POLYMERS (POLYPROPYLENE)

CAS: 9003-07-4

RTECS: UD1842000

Fraction By Weight: 1-3%

TONER POWDER MIX. (AS TOTAL NUISANCE DUST). TONER, AS A

OSHA PEL 15 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

LD50 LC50 Mixture:LD50: (ORAL, RAT) >5 G/KG.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: MINIMAL RESP TRACT IRRIT MAY
OCCUR AS W/EXPOSURE TO LGE AMT OF ANY NONTOXIC DUST. MAY CAUSE
COUGH & RAISE PHLEGM. CHRONIC: NONE. TONER PRESENTS LOW HAZ FOR
USUAL OCCUP SETTINGS. BASED ON AVAIL DATA, HUMAN EXPOSURE TO TONER
HAS BEEN SHOWN TO CAUSE MINIMAL RESP TRACT IRRIT AS MAY OCCUR W/LGE
AMTS (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OF ANY NON-TOXIC DUSTS. RSLTS OF ONE
ANIMAL STUDY WHERE RATS INHALED TONER THAT WAS 10X MORE RESPIRABLE
THAN COMMERCIALLY AVAIL TONER WERE OBSERVED TO HAVE NO LUNG CHANGES
AT LOW EXPOS (THE MOST RELEVANT LEVEL TO POTNTL HUMAN EXPOS). AT
HIGHER LEVELS A SLIGHT DEGREE OF LUNG FIBROSIS WAS OBSERVED (SUPP
DATA)
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL: WASH NOSTRILS, RINSE MOUTH. INGEST: DILUTE STOMACH
CONTENTS W/SEVERAL GLASSES OF WATER. EYES: FLUSH W/WATER FOR A
MINIMUM OF 15 MINUTES. SKIN: WASH W/SOAP & WATER.

Extinguishing Media:WATER, FOAM, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:TONER IS A COMBUSTIBLE POWDER. WHEN
DISPERSED IN AIR, IT FORMS EXPLOSIVE MIXTURES.

Spill Release Procedures:IF SPILLED, SWEEP UP OR VACUUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:NONE.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA
EQUIPMENT.
Protective Gloves:NONE REQD WHEN USED AS INTENDED.
Eye Protection:NONE REQD WHEN USED AS INTENDED.
Other Protective Equipment:NONE SPECIFIED BY MANUFACTURER.
Work Hygienic Practices:NONE.
Supplemental Safety and Health
EFTS OF OVEREXP: DUE TO EXCESSIVE AMOUNTS OF DUST RETAINED IN THE LUNGS
FOR A PROLONGED INTERVAL.

HCC:N1
Spec Gravity:1.2
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLACK POWDER, FAINT ODOR.

Stability Indicator/Materials to Avoid:YES
NONE.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:PRODUCTS OF COMBUSTION ARE TOXIC.
AVOID BREATHING OF SMOKE.

Waste Disposal Methods:DO NOT INCINERATE. NO SPECIAL TECHNIQUES BEYOND
NORMAL PRACTICE. ENSURE CONFORMITY W/FEDERAL, STATE, AND LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.